Hi i am a 79 year old scottish man, i have the same problem.ġ- do not concentrate on that mickey mouse red switch because that is not the problem.Ģ-take some dish soap and a toothbrush on clean all around the rubber gasket.ģ-try and pull on where the rubber gasket is all the way round Many auto spare shops sell silicone grease, and it is useful for many other items around the home and garage too. After I had done this, my v11 undoes the bin just fine now. DO NOT let any get onto the plastic parts, otherwise it will attract dust. When dry, apply a MINUTE amount ( a smear) of silicone grease around both seals.

When the bin/cylinder is carefully removed (gently pull and rock the bin off the main body until you can see the red release tab, press that and remove the bin), clean the mesh part on the main body with a damp cloth to remove dust particles, wipe the red seal on the bin, and the black rubber seal on the body. If the big outer lever will NOT move, and the bin is still stuck, see below:įYI: just found a solution that may work for some.

24' stand available to elevate cleaner if needed.Bear in mind that the outer red lever is pushed DOWN and AWAY from the body to release the bin, THEN when you can see the little red tab, push that toward the clear bin to release (only moves inwards about 1mm or so).

Capacities shown above are for the split flow arrangement. Capacities also vary depending on product flow through the cleaner.

*Note: capacities may vary depending on seed condition, moisture content, seed varieties, types, and volumes of contaminants to be separated and the percentage of foreign material acceptable in the final product. Rice, Oats - *60 BPH (fast clean), *35 BPH (precision clean).Soybeans, Wheat, Corn - *80 BPH (fast clean), *55 BPH (precision clean).1 Hp, 60 Hz, 1800 RPM, TEFC, 1 Phase 115/230 Volt Motor And Drive.Adjustable Bottom Air - Bottom Cleanout Air Door.3 Screens 24-1/2' x 22-1/4' Flows included: scalp, scalp, sift or scalp, split-sift.Heavy Duty 1-1/2' Eccentric Shaft, Drive and Counterbalance.This blast of air effectively removes any lightweight trash and dust that may have remained after screening.Good clean product is discharged at the bottom of the air chamber. Next, the product is routed through a column of air from the bottom blast fan. The bottom two screens can also be set up as a scalp/sift flow by removing and replacing some internal blanks. Trash, weed seeds and splits drop through the bottom screens while the good product passes over them. The bottom screen openings must be smaller than the commodity being cleaned. The bottom two screens are set up for split flow sifting. The large foreign material is 'scalped' off while the good product falls through the screen. The product then moves across the top screen, which has openings larger than the product itself. Commodity Flow: The commodity is fed into the hopper and is spread evenly across the full width of the top screen. Over 150 different sizes of perforated metal or wire cloth screens are available. The Eclipse 324 shoe has been designed with three 24-_' x 22-_' screens: One screen for the top and the other two for lower separation. The Eclipse is built with the same care and craftsmanship as Clipper's larger precision cleaners.The Clipper Eclipse 324 features a heavy-duty tubular steel frame, 13-ply marine grade plywood shoes, scotch ply hangers and a heavy-duty eccentric shoe drive. The Clipper Eclipse 324 is a small cleaner designed to meet the low maintenance and easy cleanout requirements of today's seedsman.

Clipper cleaner parts